உலகம் இனி உழவர்கள் கையில்.... தமிழின் முதல் வேளாண் நிகழ்நிலை இணையம்...

துவரை சாகுபடி (ஆங்கிலத்தில் ) Pigeon pea (Red gram) production technology

அன்பு விவசாயிகளே,
http://agrowmania.blogspot.com/ என்ற எனது வலை தளத்தில் பதிவு செய்யபட்ட துவரை சாகுபடி அனுபவ பதிவினை இங்கு மீண்டும் பதிவிடுவதில் பெருமையடைகிறேன். ஆங்கில பதிவிற்கு மண்னிக்கவும்.
Dear friends,
I have given below a brief account of pigeon pea cultivation practices as recommended by 'ICRISAT' (International Crop Research Institute for Semi Arid Tropics).

In the second part of this same article, my actual cultivation experience of pigeon pea is explained in detail.

I. Pigeon pea (Red gram, Thuvarai in Tamil) production Practices:

Native plant of India.

It's drought tolerance and the ability to use residual moisture during the dry season makes it an important crop.

It is a slow growing crop mainly cultivated in the raining season.

When cultivated in fertile soils with proper irrigation the plants attain 3 -4 m height.

At a wider spacing it may form a bush and at narrow spacing it remains compact and upright.

Root nodules of 'Rhizobia' forms on the root system.

Pigeon pea is sensitive to water logging. So, plant them in well drained soil for good root and nodule development.

Before sowing at least two ploughing is necessary. Summer ploughing helps in minimizing the weed and to conserve moisture.

Cultivation in ridges and furrows system is recommended.

* Sowing Depth: 4 to 5 cm.

Response to Nutrients:
Effect of Nitrogen is almost negligible. However a starter application of 25 kg of N / ha is beneficial.
Response to 'P' application has been positive. Application of 17 -26 kgs / ha increases yield by 300-600 kgs/ha.
Pigeon pea does not respond to K application unless it is grown on low Potassium available soils.
Most of the pigeon pea cultivars are susceptible to Zinc deficiency. So foliar application of 2-4 ppm of Zinc Sulphate @ 0.5% with 0.25 % lime
have been effective.
NPK requirement: 20 : 17 : 17

It is observed that rhizobial inoculation increase the grain yield from 19 to 68%.

IRRIGATION:

Irrigation at the time of flower initiation and pod setting are essential. The drought stress symptoms are indicated by the leaves pointing towards the
sun at noon.
Excessive moisture promotes vegetative growth. Proper irrigation increases the seed yield by about 150 - 160% over the non-irrigated control at ICRISAT.

HARVEST: It should be harvested when 80% of the pods become brown.

II. My actual cultivation experience of pigeon pea:

Initially, ICRISAT's 'ICPL 87119'- a bold seed variety was sown. But heavy monsoon rains badly affected the seeds and only about 20% germination rate was
observed. Gap filling for the remaining 80% is not feasible, so
destroyed all the plants by ploughing and opted for a fresh crop.

Next variety selected: ICPL 85063.

Area : 3 acres.

Field preparation: Ridges and furrows.

Spacing: Row to Row - 2.5 feet on ridge slope. (Actual spacing requirement for the plant is 3 feet. Do not reduce the spacing in fertile soils with irrigation
facility. The ICRISAT's recommendation of 70 cm spacing is for dry
lands.

Spacing: Plant to plant - 2 feet. (ICRISAT's recommendation of 20cm - 30cm is too narrow. Better go for above 1.5 feet - 2 feet spacing to avoid overcrowding. In my
experience, I got more grain yield from sparsely populated areas. Please note that, at a wider spacing the plant will grow as a bush and at narrow spacing it remains compact and upright.)

Seed requirement: If you sow single seed per pit, about 4 kgs (approx.) of seeds may be required for a spacing of 75cm x 60cm and if you opt for 2 seeds per pit
then about 8 kgs (approx.) of seeds will be required. The quantity of
seed requirement will also vary depending upon the size and weight of
selected seed variety.

About 1000 plants were raised in plugtrays / protrays for gap filling.

Presoaking of Seeds: Soaking the seeds in good water for 6 hours before sowing is an essential activity.

Seed Treatment: Since the procured seeds were already treated with the chemical fungicide 'Thiram', seed treatment using 'Rhizobium' was not done. So 'Rhizobium'
was broadcasted over the field.

Inter crop: Black gram in a single row on opposite side of the red gram sown ridge.
Intercrop duration: 90 days.
Deweeding: A total of 5 manual deweeding was done.
Basal :

FYM 5 Tons per Acre broadcasted before first ploughing..

Rhizobium 1 kg + Azosphyrillum 2 Kgs + Phosphobacterium 2 kgs + Viridi 500 gms were thoroughly mixed with FYM 50 Kgs and broadcasted over an acre before I irrigation.

2 Kgs of Micronutrient Mixture for Pulses (M.N. mixture No:VII in Tamilnadu) mixed with 20 kgs of sand per acre was broadcasted before III
irrigation.

Maturity / Age: 160 - 180 days.

Irrigation: To arrest the vegetative growth of the plant, irrigation was stopped by 140 th day to induce flowering.

After flowering, controlled irrigation was provided enabling the pods to get filled up.

Fertilisers:N:P:K applied was 46:32:32 against the ICRISAT recommended dosage of 20:17:17.

Top dressing of M.N Mixture 5 kg per acre on 60th day.

Foliar application of Zn So4 two times.

Pest Control:
Steps to control Pod borer attack.

Used 'Phremon traps' / 'Lures' of 'Helicoverpa armigera' @ 10 per acre at the time of flowering and changed them after 45 days with fresh ones.

Foliar spray of Bacillus thuringiensis (B.T, Brand: HALT) @ 4%/litre - 3 applications with a gap of 15 days between each spray.

Released 'Trichogramma Kilonis' an egg parasite @ 3 cc per acre (15 strips of eggs) - 3 times with a gap of 15 days between each one.

Harvesting procedure (Conventional): Cut the stem at the base ==> bundle the plants ==> shift them to
thrashing floor ==> bundles to be stacked in upright position for 2-3
days for effective drying and fall of leaves ==> beat the dry plants
with sticks ==> remove dusts and collect seeds.

Using Mechanical thrasher: By using "All purpose mechanical Thrashers", one can reduce the cost of harvesting expenses considerably.

Yield attained: Total yield 2115 Kgs in 3 acres (i.e) 705 Kgs per acre.
Yield attained from the inter crop-Blackgram: 140 Kgs per acre

Gross income per acre:

Pigeon pea:
Kgs.705 x Rs 36 = 25380

Black gram:
Kgs.140 x Rs 42 = 5880

Total income : Rs.31300

Expenses per acre:Rs. 9800 approx.

(About 50% of this expense was incurred in harvesting and for manual cleaning. I was not able to get the mechanical thrasher at the time of harvest,
though it had been booked well in advance. If I had got the mechanical
thrasher in time, I would have minimized the harvesting expenses and
the total expenses would be around Rs.7000 only)